SBR BEST AERATION

SBR best aeration

never overgrown, flexible AND EFFICIENt

CAVITECH allows you to intensify the work of MBBR and SBR

at the lowest cost.

More oxygen for more sludge
CAVITECH allows you to increase your sludge dose and dissolved oxygen concentration
Quality under the highest SBR loads
For industrial SBRs with a high content of impurities, suspended solids or fats.

Advantages

FOR YOU, FOR Eupore,

FOR the PLANET.

LET'S MAKE a DIFFERENCE

Oxygen is sufficient for high activated sludge concentrations
Increasing the energy efficiency of aeration with CAVITECH means an increase in oxygen concentration for the same energy input.
This allows you to effectively use of biofilm and other methods of fixing and increasing the concentration of activated sludge bacteria
Your SBR runs non-stop
For industrial SBR with a high content of impurities, suspended solids or fats, an important advantage of CAVITECH is the absence of an overgrowing of the aeration system.
CAVITECH always maintains the specified performance. There is no need to stop the reactor to clean the aeration system
CAVITECH increases absorption
CAVITECH increases the active sludge absorption capacity of activated sludge bacteria. The pump of the aeration module has a beneficial mechanical effect on the activated sludge. The passage of activated sludge together with wastewater through the pump and aerator leads to the disintegration of the large flakes of activated sludge into smaller ones, increasing their contact surface with the nutrients, increasing nutrition and pollutant oxidation.
CAVITECH flexibly changes performance
In the actual use of SBR, significant deviations from the input COD and BOD considered during the planning phase are possible. BOD can be significantly higher or significantly lower than planned. If the BOD concentration is consistently significantly higher, it is possible to quickly install another CAVITECH® module. When the load is reduced, you can use the pump's electric motor frequency control.

Get recommendations for choosing aeration for SBR

Email kk@cavitech.org for your request
or
send us your email for additional information

Thank you so much!

HOW TO BUY

A FEW COMMON STEPS TO A GOOD DEAL.

HOW we work

STEP 1 - YOUR REQUEST
Since you decide to try CAVITECH, you may send us your request via email kk@cavitech.org
STEP 2. A SHORT QUESTION SHEET
Since we'll get your request, we shall send you additional information and our question sheet to give you an offer tailored to the specifics of your facility.
STEP 3. DISCUSSION AND APPROVAL OF THE PROPOSAL
It will take us no more than a week to send you our technical and commercial proposal. Next, we will discuss it in detail and, if necessary, hold an on-site meeting to obtain a solution agreed upon by both parties.

Contact

GET IN TOUCH.

Request your design of an energy-saving aeration

Email kk@cavitech.org for your request
or
send us your email for additional information

Thank you so much!